Destruction of acid- and non-adapted Listeria monocytogenes during drying and storage of beef jerky Original Research Article

Presence of Listeria monocytogenes in ready-to-eat meat products is not desired and strictly regulated in the US. Inactivation of acid- and non-adapted L. monocytogenes inoculated on beef slices was studied during drying and storage of jerky formulated with modified marinades. The inoculated (five-strain composite, c. 6·2 log cfu cm−2) slices were subjected to marinades (4°C, 24 h) prior to drying (60°C for 10 h) and aerobic storage (25°C for 60 days). The predrying marinade treatments tested were, first, no treatment, control (C); second, traditional marinade (TM); third, double amount of TM modified with 1·2% sodium lactate, 9% acetic acid, and 68% soy sauce containing 5% ethanol (MM); fourth, dipping into 5% acetic acid for 10 min and then applying the TM (AATM); and fifth dipping into 1% Tween 20 for 15 min and then into 5% acetic acid for 10 min followed by the TM (TWTM). Bacterial survivors on beef slices were determined during drying and storage using tryptic soy agar with 0·1% pyruvate (TSAP), and PALCAM agar. Results indicated that drying reduced bacterial populations in the order of pre-drying treatments TWTM (5·9–6·3 log cfucm−2 in 10 h)≥AATM≥MM>TM≥C (3·8−4·6 log cfucm−2 in 10 h). No significant (P≥0·05) difference was found in inactivation of acid-adapted and non-adapted inocula within individual treatments. Bacterial populations dropped below the detection limit (−0·4 log cfucm−2) as early as 4 h during drying or remained detectable even after 60 days of storage depending on acid-adaptation, predrying treatment, and agar media. These results indicated that acid-adaptation may not increase resistance to microbial hurdles involved in jerky processing and that use of modified marinades may improve the effectiveness of drying in inactivating L. monocytogenes.