Removal of nitrogen from wastewater for reusing to boiler feed-water by an anaerobic/aerobic/membrane bioreactor

The innovative process anaerobic/aerobic/membrane bioreactor (A/O/MBR) was developed to enhance pre-denitrification without the energy consumption of the recirculation pump for reusing wastewater to boiler feed-water. The performance of this bioreactor was investigated. Firstly, the septic tank wastewater with low ratio of COD/TN was disposed by a dynamic membrane bioreactor (DMBR). It was found that, although the high concentration of NO2−–N in the effluent implied the potential ability of DMBR to realize shortcut nitrification and denitrification, the effluent of single DMBR was difficult to reach the criteria of reusing to boiler feed-water. Then, the process A/O/DMBR in disposing the septic tank wastewater was studied. The results indicated that this process not only accomplished the removal of 91.5% COD, 90.3% NH4 +–N and 60.2% TN, but also successfully realized pre-denitrification without additional recirculation pump. At last, based on the A/O/DMBR, a pilot plant A/O/MBR was built to dispose the municipal raw sewage. In the stable operation period, the average removal efficiencies for COD, NH4 +–N, TP and turbidity reached 90%, 95%, 70% and 99%, respectively. During the tested HRT run of 9.0 h, the effluent of COD, NH4 +–N, TP and turbidity was about 10 mg/L, 3 mg/L, below 1 mg/L and 1.2 NTU, respectively, which reached the criteria of the boiler feed-water in China.