Crystallization and enzymatic degradation of novel poly(ε-caprolactone-co-propylene succinate) copolymers

A series of novel poly(ε-caprolactone-co-propylene succinate) P(CL-co-PSu) copolymers having low propylene succinate content and high molecular weight were synthesized following a combinatory scheme of ring opening and polycondensation reactions, in an attempt to obtain copolymers of sufficient performance and increased biodegradation rates. Enzymatic hydrolysis of the copolymers was studied in the presence of mixture of Rhizopus delemar and Pseudomonas cepacia lipases. Much higher hydrolysis rates, comparing to neat PCL, were proved by both mass loss measurements and scanning electron microscopy (SEM) observations of the degraded film surfaces. Thermodynamics of cocrystallization and wide-angle X-ray diffraction (WAXD) patterns were investigated to estimate the extent of comonomer cocrystallization. Results of the study showed that comonomer inclusion may hold, though the molar fraction of the comonomer in the PCL crystals is lower than in the bulk. This means that not only the observed decrease of the degree of crystallinity from about 48% for PCL to about 29% for the P(CL-co-PSu) 75/25 favours enzymatic hydrolysis, but also the enrichment of the amorphous phase in the fast degrading propylene succinate units plays its role. The non-isothermal crystallization rates of the copolymers, like the melting points, decreased substantially when the propylene succinate content exceeded 8 mol%. The activation energy of crystallization was calculated using the isoconversional method of Friedman, over the whole range of crystallization temperatures. An increase was found in the activation energy with increasing the comonomer content in the copolymers also proving the reduced symmetry along the copolymer chains due to the presence of comonomer units.