The effect of time and type of electrical stimulation on the calpain system and meat tenderness in beef longissimus dorsi muscle

Effects of type and time of electrical stimulation on the calpain system, sensory and objective meat quality in the M. longissimus thoracis et lumborum from 38 pasture-fed carcasses, were investigated under conventional chilling conditions. High voltage stimulation was applied to whole carcasses at 3 min post-mortem (pm) and to sides at either 40 or 60 min pm, whilst low voltage stimulation was applied to whole carcasses at 3 min pm and to sides at 40 min pm. Unstimulated sides served as controls. The levels of extractable μ-calpain and calpastatin decreased during stimulation by 28–44% and 8–17%, respectively. Shear force and adjusted tenderness score showed that stimulation at 3 min, irrespective of type of stimulation, resulted in significantly tougher meat (P<0.05) which was associated with an rapid rate of pH decline, compared to stimulation at 40 min. Higher calpastatin levels soon after stimulation at 3 min (P < 0.05) and lower μ-calpain level at 24 h pm for high voltage stimulation at 3 min (P<0.05) coincided with the tougher meat. On the other hand, high voltage stimulation at 40 and 60 min resulted in similar tenderness and levels of μ-calpain and calpastatin post-stimulation and 24 h pm. Significantly tougher meat from the control sides, with a higher μ-calpain levels at 24 h pm and similar sarcomere length, compared to those from low voltage stimulation at 40 min (P<0.001), appeared to be linked to the later activation of the calpain system. Results from the current study suggest that early application of stimulation may be associated with a very rapid decline in pH and consequently a reduction in meat quality.