Unusual crystals of poly(ε-caprolactone) by unusual crystallisation: The effects of rapid cooling and fast solvent loss on the morphology, crystal structure and melting

The lateral habit, unit cell structure and melting behaviour of single crystals of poly(ε-caprolactone) (PCL) prepared by the rapid expansion of a supercritical solution technique was studied by AFM at ambient and higher temperatures and by grazing-incident X-ray scattering using a synchrotron source. After dissolving PCL in a solution of supercritical CO2 and 0.1 vol.% chloroform, an extremely fast phase transfer from a supercritical to a gas-like state occurred during expansion into atmospheric conditions, leading to a temporary temperature drop to below −50 °C at the silica surface where the crystals were deposited. Single crystals of a hitherto unreported rectangular lateral habit were observed. Six-sided crystals were also observed, but they were fewer than the rectangular crystals and in addition the angles between the lateral faces were different from the theoretical angles between adjacent {110} faces and {110} and {100} faces. X-ray scattering indicated a polymorphic structure also including the orthorhombic (110) and (200) diffraction peaks. Distinct low angle peaks essentially along the c-axis indicated a stacking on a very fine scale (3.7–4.7 nm) within the crystals. The equatorial diffraction peaks indicated a less dense packing of the PCL stems. Rectangular single crystals with a height according to AFM of 11–27 nm melted between 40 and 45 °C, which is lower than the melting points (55 °C) recorded for the distorted six-sided crystals. The unusual conditions for crystallisation used gave the polymer molecules a severe limitation to rearrange from the initial random coil state. The facetted crystals consisted of a stack of 4 nm thick blocks; these blocks most probably constituted a regular variation in molecular packing, i.e. molecular order. The pronounced changes in the angles between adjacent faces from those observed in mature PCL crystals and the wide-angle X-ray scattering data indicated the presence of conformational disorder in the crystals.