Anaerobic digestion of municipal solid waste as a treatment prior to landfill

Anaerobic digestion of organic fraction of municipal solid waste was conducted in pilot-scale reactor based on high-solid combined anaerobic digestion process. This study was performed in two runs. In Run 1 and Run 2, pre-stage flushing and micro-aeration were conducted to determine their effect in terms of enhancing hydrolysis and acidification in ambient condition. In Run 2, after pre-stage, the methane phase (methanogenesis) was started-up after pH adjustment and inoculum addition in mesophilic condition. Acidified leachate produced in pre-stage was used for percolation during active methane phase. At the end of methane phase, air flushing was conducted before unloading the digesters. Hydrolysis and acidification yield of 140 g C/kg TS and 180 g VFA/kg TS were achieved, respectively in pre-stage. Micro-aeration exhibited an equivocal result in terms of enhancing hydrolysis/acidification; however it showed a positive effect in methane phase performance and this needed further investigation. Leachate percolation during methane phase showed an enhanced methanization when compared to the reactors without leachate percolation. After 60 days, 260 l CH4/kg VS was obtained. Based on the waste methane potential, 75% biogas conversion and 61% VS degradation were achieved.